다결정 3C-SiC 멤브레인 위에 균일한 온도분포를 갖는 마이크로 히터의 제작과 그 특성
Fabrication of micro heaters with uniform-temperature area on poly 3C-SiC membrane and its characteristics
2
조회
0
다운로드
0
인용
0
참고문헌
키워드
초록
This paper describes the fabrication and characteristics of micro heaters built on AlN(0.1 μm)/3C-SiC(1 μm) suspended membranes by surface micromachining technology. In this work, 3C-SiC and AlN films are used for high temperature environments. Pt thin film was used as micro heaters and temperature sensor materials. The resistance of temperature sensor and the power consumption of micro heaters were measured and calculated. The heater is designed for operating temperature up to about 800 ℃ and can be operated at about 500 ℃ with a power of 312 mW. The thermal coefficient of the resistance(TCR) of fabricated Pt resistance of temperature detector(RTD)'s is 3174.64 ppm/℃. A thermal distribution measured by IR thermovision is uniform on the membrane surface.
Abstract
This paper describes the fabrication and characteristics of micro heaters built on AlN(0.1 μm)/3C-SiC(1 μm) suspended membranes by surface micromachining technology. In this work, 3C-SiC and AlN films are used for high temperature environments. Pt thin film was used as micro heaters and temperature sensor materials. The resistance of temperature sensor and the power consumption of micro heaters were measured and calculated. The heater is designed for operating temperature up to about 800 ℃ and can be operated at about 500 ℃ with a power of 312 mW. The thermal coefficient of the resistance(TCR) of fabricated Pt resistance of temperature detector(RTD)'s is 3174.64 ppm/℃. A thermal distribution measured by IR thermovision is uniform on the membrane surface.
참고문헌 (7)
- J. C. Lee, "Electrical, thermal, and mechanical characterization of silicon microcantilever heaters", J. Microelectromech. Syst, 15(6), pp.1644~1655 (2006)
- G. Wiche, "Thermal analysis of silicon carbide based microhotplates for metal oxide gas sensors", Sen. Actu. A, 123, pp.12~17 (2005)
- W. C. Choi, "Thermal characteristics of microheater for gas sensors", J. Kor. Sensors. Soc, 7(5), pp.57~63 (1998)
- F. Solzbacher, "A modular system of SiC-based microhotplates for the application in metal oxide gas sensors", Sen. Actu. B, 64, pp.95~101 (2000)
- 한기봉, "순 아르콘 캐리어 가스와 APCVD로 성장된 다결정 3C-SiC 박막의 기계적 특성", 센서학회지, 16(4), pp.319~323 (2007), 한국센서학회
- G. S. Chung, "Fabrication and characterization of micro-heaters with low-power consumption using SOI membrane and trench structures", Sen. Actu. A, 112, pp.55~60 (2004)
- 정귀상, "AlN 버퍼층위에 성장된 M", NEMS용 다결정 3C-SiC 박막의 특성, 2007, pp.16(6), 457~461[DOI]