입사광량의 조절과 이에 따른 비분산 적외선 알코올 센서의 온도 특성과 보정
Temperature Compensation and Characteristics of Non-dispersive Infrared Alcohol Sensor According to the Intensity of Light
2
조회
0
다운로드
1
인용
0
참고문헌
키워드
초록
In this paper, we describe the thermal characteristics of the output voltages of ethanol gas sensor according to the amount of radiation incident on the infrared sensors located at each focal point of two elliptical waveguides. In order to verify the output characteristics of the gas sensor according to the amount of incident light on the infrared sensor, two combinations of sensor modules were fabricated. Hydrophobic thin film is deposited on one of the reflectors of sensor modules and one of the two infrared sensors was equipped witha hollow disk (1.0 Ø), and the temperature characteristics of the infrared sensor equipped with the hollow disk (1.0 Ø) and the infraredsensor without the disk were tested. The temperature was varied from 253 K to 333 K at 10 K intervals based on 298 K. The properties of ethanol gas sensor have been identified with respect to varying temperature for a range of ethanol concentration from 0 ppm to 500ppm. In the case of an infrared sensor equipped with a hollow disk (1.0 Ø), the output voltage of the sensor decreased by 0.8 mV and1 mV, respectively, as the temperature increased. Conversely, the output voltage of the diskless infrared sensor showed an averageincrease of 67 mV and 57 mV as the temperature increased. The ethanol concentrations estimated on the basis of results show an error of more than 10 % for less than 100 ppm concentration. However, if the ethanol concentration exceeds 100 ppm, the gas concentration can be estimated within the range of ±10%.
Abstract
In this paper, we describe the thermal characteristics of the output voltages of ethanol gas sensor according to the amount of radiation incident on the infrared sensors located at each focal point of two elliptical waveguides. In order to verify the output characteristics of the gas sensor according to the amount of incident light on the infrared sensor, two combinations of sensor modules were fabricated. Hydrophobic thin film is deposited on one of the reflectors of sensor modules and one of the two infrared sensors was equipped witha hollow disk (1.0 Ø), and the temperature characteristics of the infrared sensor equipped with the hollow disk (1.0 Ø) and the infraredsensor without the disk were tested. The temperature was varied from 253 K to 333 K at 10 K intervals based on 298 K. The properties of ethanol gas sensor have been identified with respect to varying temperature for a range of ethanol concentration from 0 ppm to 500ppm. In the case of an infrared sensor equipped with a hollow disk (1.0 Ø), the output voltage of the sensor decreased by 0.8 mV and1 mV, respectively, as the temperature increased. Conversely, the output voltage of the diskless infrared sensor showed an averageincrease of 67 mV and 57 mV as the temperature increased. The ethanol concentrations estimated on the basis of results show an error of more than 10 % for less than 100 ppm concentration. However, if the ethanol concentration exceeds 100 ppm, the gas concentration can be estimated within the range of ±10%.
참고문헌 (13)
- 경찰청, "음주운전 삼진아웃 처분현황", ~ (2017)
- California legislative, "SB-1046 Driving under the in-fluence: ignition interlock device" (2016)
- G. S. Ranganath, "Black-Body Radiation", J. Sci. Educ., 13(2) (2008)
- L. Ma1, "Two forms of Wien's dis-placement law", Lat. Am. J. Phys. Educ., 3(3) (2009)
- R.V. Maikala, "Modified Beer's law-historical perspec-tives and relevance in near-infrared monitoring of optical properties of human tissue", Inter. J. Ind. Ergonomics, 40, pp.125~134 (2010)[DOI]
- 환경부, "비분산적외선 방식의 보급형 일산화탄소 가스 센서 개발" (2009)
- J.M. Park, "Novel NDIR CO2 sensor with two concave mirrors", Proc. Of APCOT2006 (2006)
- 장성호, "두 개의 동일한 타원형 구조를 지닌 광 도파관의 특성", 한국가스학회지, 18(2), pp.48~54 (2014), 한국가스학회[DOI]
- 이승환, "White-Cell구조를 응용한 비분산 적외선 이산화탄소 센서의 온도특성", 센서학회지, 25(5), pp.377~381 (2016), 한국센서학회[DOI]
- 이승환, "보상용 적외선 센서를 사용한 비분산 적외선 이산화탄소 센서의 온도특성", 센서학회지, 25(2), pp.124~130 (2016), 한국센서학회[DOI]
- S. Kim, "Derivation of the center-wave length shift of narrow-bandpass filter under temperature change", Opt. Express, 12(23), pp.5634~5639 (2004)[DOI]
- C.N Chen, "Fully quantitative characterization of CMOSMEMS polysilicon", titanium thermopile infrared sensors, 2012, pp.161, 892~900