탈휘발 과정과 촤가스화 과정에서 목질계 바이오매스의 타르발생 특성
Characteristics of Tar Generation during the interval of Gasification of Woodchip
2
조회
0
다운로드
4
인용
0
참고문헌
키워드
초록
Biomass gasification is a promising technology in terms of clean energy and flexible options for end use such as heat, steam, electricity, gaseous or liquid fuels. In a gasification process, reduction of tar is very important because it can cause any mechanical problems and small tar implies high energy efficiency. However, generation and conversion mechanisms of tar have not been fully understood due to its complex nature. In this study, characteristics of tar generated from different gasification stages were investigated. Korean pine woodchip was used as feedstock and tar was sampled in a separate way during devolatilization and char gasification stage, investigated. As a result, more various kinds of hydro carbon compounds were identified in the devolatilization stage than char gasification stage because primary tar compounds are released mostly from pyrolysis of cellulose and hemicellulose. When the reaction temperature increased up to 900oC, tar composition becomes simplified into about 10 aromatic compounds mostly with 1-4 rings without substitution up to phenanthrene. The sampled tar in the char gasification stage mostly contains 5-7 simple aromatic compounds.
Abstract
Biomass gasification is a promising technology in terms of clean energy and flexible options for end use such as heat, steam, electricity, gaseous or liquid fuels. In a gasification process, reduction of tar is very important because it can cause any mechanical problems and small tar implies high energy efficiency. However, generation and conversion mechanisms of tar have not been fully understood due to its complex nature. In this study, characteristics of tar generated from different gasification stages were investigated. Korean pine woodchip was used as feedstock and tar was sampled in a separate way during devolatilization and char gasification stage, investigated. As a result, more various kinds of hydro carbon compounds were identified in the devolatilization stage than char gasification stage because primary tar compounds are released mostly from pyrolysis of cellulose and hemicellulose. When the reaction temperature increased up to 900oC, tar composition becomes simplified into about 10 aromatic compounds mostly with 1-4 rings without substitution up to phenanthrene. The sampled tar in the char gasification stage mostly contains 5-7 simple aromatic compounds.
참고문헌 (15)
- 김영두, "기포 유동층을 이용한 바이오매스 가스화 시스템 연구", 한국연소학회 추계 심포지움 2009 (2009), 한국연소학회
- 정효재, "폐기물 열분해 합성가스를 이용한 발전용 엔진구동에 대한 실험적 연구", 한국연소학회지, 15(3), pp.48~56 (2010), 한국연소학회
- Y.H. Qin, "Formation of tar and its characterization during air-steam gasification of sawdust in a fluidized bed reactor", Energy, Fuel (2009)
- C. Li, "Tar property, analysis, reforming mechanism and model for biomass gasification - An overview", Renewable and Sustainable Energy Reviews. Sci, 13, pp.594~604 (2009)
- P. Morf, "Mechanisms and kinetics of homogeneous secondary reactions of tar from continuous pyrolysis of wood chips", Fuel, 81, pp.843~853 (2002)
- C. Myrén, "Catalytic tar decomposition of biomass pyrolysis gas with a combination of dolomite and silica", Biomass and Bioenergy, 23, pp.217~227 (2002)
- C. Pfeifer, "Development of catalytic tar decomposition downstream from a dual fluidized bed biomass steam gasifier", Powder Technology, 180, pp.9~16 (2008)
- Maniatis K, "Tar Protocols. IEA Bioenergy Gasification Task", Biomass Bioenergy, 18(1), pp.1~4 (2000)
- 박영철, "등온법에 의한 석탄 촤연소반응 및 촤-수증기 반응특성", 화학공학, 29(3), pp.323~ (1991)
- J.P.A. Neeft, "GUIDELINE FOR SAMPLING AND ANALYSIS OF “TARS” AND PARTICLES IN BIOMASS PRODUCER GASES, ECN-RX-00-026", 29~40
- 문지홍, "탈휘발 과정과 촤 가스화 과정에서 우드칩 연료의 타르발생 특성의 변화", 한국열환경공학회 춘계 심포지움 2010 (2010), 한국열환경공학회
- 성연경, "Tube furnace를 이용한 바이오매스의 스팀 가스화 연구", 한국연소학회 추계 학술발표회 논문집, pp.255~258 (2009), 한국연소학회
- Rationale for setup of impinger train - as used in the Technical Specification of Sampling and Analysis of Tar and Particles in the Product Gases of Biomass Gasification, "J.P.A. Neeft", ~, pp.CEN BT (2005), TF 143
- Sampling and analysis of tar and particles in biomass producer gases - Technical Report, "J. Good", ~, pp.CEN BT (2005), TF 143
- Biomass gasifer ‘tars: their nature, formation and convertsion, "T.A. Milne", National Renewable Energy Laboratory, ~, pp.NREL (1998), TP-570-25357