미분탄 스월버너에서 PKS와 석탄 혼소가 화염 구조에 미치는 영향
Effect of Co-firing PKS and Coal on Flame Structure in a Pulverized Coal Swirl Burner
1
조회
0
다운로드
1
인용
0
참고문헌
키워드
초록
Flame structure of co-firing coal and palm kernel shell (PKS) was investigated in a pulverized coal swirl burner by particle image velocimetry (PIV). The pulverized coal swirl flame is operated with a PKS blending ratio of 10%, 20%, and 30%. For all operating conditions, flame structures such as internal recirculation zone (IRZ), outer recirculation zone (ORZ), and exhaust tube vortex (ETV) were observed. In the center of flame, the strong velocity gradient is occurred at the stagnation point where the volatile gas combustion actively takes place and the acceleration is increased with higher PKS blending ratio. OH radical shows the burned gas region at the stagnation point and shear layer between IRZ and ORZ. In addition, OH radical intensity increases for a co-firing condition because of high volatile matter from PKS. Because the volatile gas combustion takes place at lower temperature, co-firing condition (more than 20%) leads to oxygen deficiency and reduces the combustibility of coal particle near the burner. Therefore, increasing PKS blending ratio leads to higher OH radical intensity and lower temperature.
Abstract
Flame structure of co-firing coal and palm kernel shell (PKS) was investigated in a pulverized coal swirl burner by particle image velocimetry (PIV). The pulverized coal swirl flame is operated with a PKS blending ratio of 10%, 20%, and 30%. For all operating conditions, flame structures such as internal recirculation zone (IRZ), outer recirculation zone (ORZ), and exhaust tube vortex (ETV) were observed. In the center of flame, the strong velocity gradient is occurred at the stagnation point where the volatile gas combustion actively takes place and the acceleration is increased with higher PKS blending ratio. OH radical shows the burned gas region at the stagnation point and shear layer between IRZ and ORZ. In addition, OH radical intensity increases for a co-firing condition because of high volatile matter from PKS. Because the volatile gas combustion takes place at lower temperature, co-firing condition (more than 20%) leads to oxygen deficiency and reduces the combustibility of coal particle near the burner. Therefore, increasing PKS blending ratio leads to higher OH radical intensity and lower temperature.
참고문헌 (26)
- A. Demirbas, "Combustion Characteristics of Different Biomass Fuels", Prog. Energy Combust. Sci, 30, pp.219~230 (2004)
- L. Baxter, "Biomass-Coal Co-Combustion: Opportunity for Affordable Renewable Energy", Fuel, 84, pp.1295~1302 (2005)
- T. Nussbaumer, "Combustion and Co-Combustion of Biomass: Fundamentals, Technologies, and Primary Measures for Emission Reduction", Energy Fuels, 17, pp.1510~1521 (2003)
- G.J. Hesselmann, "Optimization of Combustion by Fuel Testing in a NOx Reduction Test Facility", Fuel, 76, pp.1269~1275 (1997)
- S. Munir, "The Effect of Air Staged, Co-Combustion of Pulverised Coal and Biomass Blends on NOx Emissions and Combustion Efficiency", Fuel, 90, pp.126~135 (2011)
- D.E. Priyanto, "Ash Transformation by Co-Firing of Coal with High Ratios of Woody Biomass and Effect on Slagging Propensity", Fuel, 174, pp.172~179 (2016)
- J. Chacon, "Investigation on the Design and Optimization of a Low NOx-CO Emission Burner Both Experimentally and through Computational Fluid Dynamics (CFD) Simulations", Energy Fuels, 21, pp.42~58 (2007)
- Z. Chen, "Gas", Particle Flow and Combustion Characteristics and NOx Emissions of a New Swirl Coal Burner, 2011, pp.36, 709~723
- R. Luo, "Experimental Study on Flow and Combustion Characteristic of a Novel Swirling Burner Based on Dual Register Structure for Pulverized Coal Combustion", Exp. Therm. Fluid Sci, 54, pp.136~150 (2014)
- M. Gu, "The Effect of the Mixing Characters of Primary and Secondary Air on NOx Formation in a Swirling Pulverized Coal Flame", Fuel, 84, pp.2093~2101 (2005)
- J.O.L. Wendt, "Fundamental Coal Combustion Mechanisms and Pollutant Formation in Furnaces", Prog. Energy Combust. Sci, 6, pp.210~222 (1980)
- S. Fan, "Influence of Outer Secondary-Air Vane Angle on Combustion Characteristics and NOx Emissions of a Down-Fired Pulverized-Coal 300 MWe Utility Boiler", Fuel, 89, pp.1525~1533 (2010)
- S. Ti, "Influence of Different Swirl Vane Angles of Over Fire Air on Flow and Combustion Characteristics and NOx Emissions in a 600 MWe Utility Boiler", Energy, 74, pp.775~787 (2014)
- S. Balusamy, "Laser Diagnostics of Pulverized Coal Combustion in O2", N2 and O2, Exp. Fluids, pp.2015, 56[DOI]
- M. Stöhr, "Experimental Study of Vortex-Flame Interaction in a Gas Turbine Model Combustor", Combust. Flame, 159, pp.2636~2649 (2012)
- G. Bulat, "Large Eddy Simulations of Isothermal Confined Swirling Flow in an Industrial Gas-Turbine", Int. J. Heat Fluid Flow, 51, pp.50~64 (2015)
- Y. Sung, "Optical Non-Intrusive Measurements of Internal Recirculation Zone of Pulverized Coal Swirling Flames with Secondary Swirl Intensity", Energy, 103, pp.61~74 (2016)
- Y. Sung, "Non-Intrusive Optical Diagnostics of Co- and Counter-Swirling Flames in a Dual Swirl Pulverized Coal Combustion Burner", Fuel, 174, pp.76~88 (2016)
- F. Akamatsu, "The Development of a Light-Collecting Probe with High Spatial Resolution Applicable to Randomly Fluctuating Combustion Fields", Meas. Sci. Technol, 10, pp.1240~1246 (1999)
- J.R. Kim, "Observation of Local Heat Release Rate with Changing Combustor Pressure in the CH4", Air Flame (Wrinkled Laminar Regime), 2009, pp.491, 109~115
- C. Yin, "Towards a Better Understanding of Biomass Suspension Co-Firing Impacts Via Investigating a Coal Flame and a Biomass Flame in a Swirl-Stabilized Burner Flow Reactor Under Same Conditions", Fuel Process. Technol, 98, pp.65~73 (2012)
- S. Hwang, "Application of Optical Diagnostics Techniques to a Laboratory-Scale Turbulent Pulverized Coal Flame", Energy Fuels, 19, pp.382~392 (2005)
- Y. Sung, "Generation Mechanism of Tube Vortex in Methane-Assisted Pulverized Coal Swirling Flames" (2016), Fuel Process. Technol
- 김대희, "연소중 미분탄의 발광 분석 및 입자 채집 관찰", 한국연소학회지, 15(2), pp.19~26 (2010), 한국연소학회
- 안재우, "미분탄과 목재 바이오매스 혼합 연료의 연소 및 열분해 특성에 관한 연구", 한국연소학회지, 15(2), pp.34~40 (2010), 한국연소학회
- M.A. Serio, "Kinetics of Volatile Product Evolution in Coal Pyrolysis: Experiment and Theory", Energy Fuels, 1, pp.138~152 (1987)