Validation and Recommendation of Methods to Measure Biogas Production Potential of Animal Manure
0
조회
0
다운로드
4
인용
0
참고문헌
키워드
초록
In developing countries, biogas energy production is seen as a technology that can provide clean energy in poor regions and reduce pollution caused by animal manure. Laboratories in these countries have little access to advanced gas measuring equipment, which may limit research aimed at improving local adapted biogas production. They may also be unable to produce valid estimates of an international standard that can be used for articles published in international peer-reviewed science journals. This study tested and validated methods for measuring total biogas and methane (CH4) production using batch fermentation and for characterizing the biomass. The biochemical methane potential (BMP) (CH4 NL kg-1 VS) of pig manure, cow manure and cellulose determined with the Moller and VDI methods was not significantly different in this test (p>0.05). The biodegradability using a ratio of BMP and theoretical BMP (TBMP) was slightly higher using the Hansen method, but differences were not significant. Degradation rate assessed by methane formation rate showed wide variation within the batch method tested. The first-order kinetics constant k for the cumulative methane production curve was highest when two animal manures were fermented using the VDI 4630 method, indicating that this method was able to reach steady conditions in a shorter time, reducing fermentation duration. In precision tests, the repeatability of the relative standard deviation (RSDr) for all batch methods was very low (4.8 to 8.1%), while the reproducibility of the relative standard deviation (RSDR) varied widely, from 7.3 to 19.8%. In determination of biomethane concentration, the values obtained using the liquid replacement method (LRM) were comparable to those obtained using gas chromatography (GC). This indicates that the LRM method could be used to determine biomethane concentration in biogas in laboratories with limited access to GC.
Abstract
In developing countries, biogas energy production is seen as a technology that can provide clean energy in poor regions and reduce pollution caused by animal manure. Laboratories in these countries have little access to advanced gas measuring equipment, which may limit research aimed at improving local adapted biogas production. They may also be unable to produce valid estimates of an international standard that can be used for articles published in international peer-reviewed science journals. This study tested and validated methods for measuring total biogas and methane (CH4) production using batch fermentation and for characterizing the biomass. The biochemical methane potential (BMP) (CH4 NL kg-1 VS) of pig manure, cow manure and cellulose determined with the Moller and VDI methods was not significantly different in this test (p>0.05). The biodegradability using a ratio of BMP and theoretical BMP (TBMP) was slightly higher using the Hansen method, but differences were not significant. Degradation rate assessed by methane formation rate showed wide variation within the batch method tested. The first-order kinetics constant k for the cumulative methane production curve was highest when two animal manures were fermented using the VDI 4630 method, indicating that this method was able to reach steady conditions in a shorter time, reducing fermentation duration. In precision tests, the repeatability of the relative standard deviation (RSDr) for all batch methods was very low (4.8 to 8.1%), while the reproducibility of the relative standard deviation (RSDR) varied widely, from 7.3 to 19.8%. In determination of biomethane concentration, the values obtained using the liquid replacement method (LRM) were comparable to those obtained using gas chromatography (GC). This indicates that the LRM method could be used to determine biomethane concentration in biogas in laboratories with limited access to GC.
참고문헌 (30)
- Abu-Dahrieh, J., "Batch and continuous biogas production from grass silage liquor", Bioresour. Technol, 102, pp.10922~10928 (2011)
- Angelidaki, I., "Anaerobic thermophilic digestion of manure at different ammonia loads: effect of temperature", Water Res, 28, pp.727~731 (1994)
- Angelidaki, I., "Defining the biomethane potential (BMP) of solid organic wastes and energy crops: a proposed protocol for batch assays", Water Sci. Technol, 59, pp.927~934 (2009)
- APHA, "Standard Methods for the Examination of Water and Wastewater (21st ed.)" (2005), American Public Health Association
- Bhattacharya, S. C., "Renewable energy in India : historical developments and prospects", Energy, 34, pp.981~991 (2009)
- Bouwman, A. F., "Exploring global changes in nitrogen and phosphorus cycles in agriculture induced by livestock production over the 1900-2050 period", Proc. Natl. Acad. Sci. USA (2012)
- Chen, Y., "Inhibition of anaerobic digestion process: a review", Bioresour. Technol, 99, pp.4044~4064 (2008)
- Cu, T. T. T., "Manure management practices on biogas and non-biogas pig farms in developing countries - using livestock farms in Vietnam as an example", J. Clean Prod, 27, pp.64~71 (2012)
- Davidson, E. A., "The contribution of manure and fertilizer nitrogen to atmospheric nitrous oxide since 1860", Nat. Geosci, 2, pp.659~662 (2009)
- Demirer, G. N., "Anaerobic treatability and biogas production potential studies of different agro-industrial wastewaters in Turkey", Biodegradation, 11, pp.401~405 (2000)
- Godfray, H. C., "Food security : The challenge of feeding 9 billion people", Science, 327, pp.812~818 (2010)
- Guwy, A. J., "Equipment used for testing anaerobic biodegradability and activity", Rev. Environ. Sci. Biotechnol, 3, pp.131~139 (2004)
- Hansen, T. L., "Method for determination of methane potentials of solid organic waste", Waste Manag, 24, pp.393~400 (2004)
- Hansen, T. L., "Methane production during storage of anaerobically digested municipal organic waste", J. Environ. Qual, 35, pp.830~836 (2006)
- Jiang, X., "A review of the biogas industry in China", Energy Policy, 39, pp.6073~6081 (2011)
- Kiilholma, J. K., "Hygienic Aspects of Effluent Use from Small-Scale Biogas Digesters in Northern Vietnam", 석사, pp.2009
- Lahav, O., "Rapid, simple and accurate method for measurement of VFA and carbonate alkalinity in anaerobic reactors", Environ. Sci. Technol, 36, pp.2736~2741 (2002)
- Møller, H. B., "Methane productivity of manure, straw and solid fractions of manure", Biomass Bioenergy, 26, pp.485~495 (2004)
- Raposo, F., "Influence of inoculum to substrate ratio on the biochemical methane potential of maize in batch tests", Process Biochem, 41, pp.1444~1450 (2006)
- Raposo, F., "Biochemical methane potential (BMP) of solid organic substrates: evaluation of anaerobic biodegradability using data from an international inter-laboratory study", J. Chem. Technol. Biotechnol, 86, pp.1088~1098 (2011)
- Rozzi, A., "Methods of assessing microbial activity and inhibition under anaerobic conditions: a literature review", Rev. Environ. Sci. Biotechnol, 3, pp.93~115 (2004)
- Shahriari, S., "Anaerobic digestion of organic fraction of municipal solid waste combining two pretreatment modalities, high temperature microwave and hydrogen peroxide", Waste Manag, 32, pp.41~52 (2012)
- Sommer, S. G., "Algorithms for calculating methane and nitrous oxide emissions from manure management", Nutr. Cycl. Agroecosyst, 69, pp.143~154 (2004)
- Sutton, M. A., "Too much of a good thing", Nature, 472, pp.159~161 (2011)
- Symons, G. E., "The methane fermentation of carbohydrates", J. Am. Chem. Soc, 55, pp.2028~2036 (1933)
- Triolo, J. M., "A new algorithm to characterize biodegradability of biomass during anaerobic digestion: Influence of lignin concentration on methane production potential", Bioresour. Technol, 102, pp.9395~9402 (2011)
- Triolo, J. M., "Biochemical methane potential and anaerobic biodegradability of non-herbaceous and herbaceous phytomass in biogas production", Bioresour. Technol, 125, pp.226~232 (2012)
- VDI, "VDI 4630: Fermentation of organic materials - Characterisation of the substrate, sampling, collection of material data, fermentation tests, In Verein Deutscher Ingenieure (VDI)", pp.44~59 (2006), Beuth Verlag GmbH
- Vu, T. K. V., "A survey of manure management on pig farms in northern Vietnam", Livest. Sci, 112, pp.288~297 (2007)
- Xiong, Z. Q., "Impacts of population growth, changing food preferences and agricultural practices on the nitrogen cycle in East Asia", Nutr. Cycl. Agroecosyst, 80, pp.189~198 (2008)