Influence of Compost Recycling and Magnesium Supplement on Physical and Chemical Traits of Animal Manure Compost
2
조회
0
다운로드
1
인용
0
참고문헌
키워드
초록
A series of experiments were performed to study the influence of the following parameters on the physical traits and composition of swine manure compost: (1) addition of magnesium(Mg) at a molar ratio of 1.2 with respect to PO4, and (2) reutilization of compost containing MgNH4PO4·6H2O(magnesium ammonium phosphate, MAP). Three independent batch tests were conducted for replication: batch test I-control(C) and Mg added(T), batch test II-C, T and compost recycle(TR1), and batch test III-C, T and compost recycle(TR2). Magnesium addition and compost reutilization had no adverse effect on the degradation of organic matter. Reuse of the compost, however, had a clear effect on the total nitrogen(TN) and total phosphorus(TP) contents in the final compost. Repeated compost reutilization as a bulking material was resulted in composts rich in N and P. Upon adding the Mg supplement to the composting materials, the ortho-phosphate(OP) to TP ratio decreased due to the MAP crystallization reaction. The decrease in the OP/TP ratio and the increase in the TP content of the compost indicate that water-soluble phosphate is converted into a slow-release phosphate by the formation of crystals during composting. X-ray diffraction analysis of the irregular shaped crystals in the compost indicated that they are MAP crystals and that the crystallization of MAP begins immediately after the addition of the Mg supplement. The Mg addition to composting materials and the reutilization of compost as a bulking material would be a practical means to conserve nutrient content.
Abstract
A series of experiments were performed to study the influence of the following parameters on the physical traits and composition of swine manure compost: (1) addition of magnesium(Mg) at a molar ratio of 1.2 with respect to PO4, and (2) reutilization of compost containing MgNH4PO4·6H2O(magnesium ammonium phosphate, MAP). Three independent batch tests were conducted for replication: batch test I-control(C) and Mg added(T), batch test II-C, T and compost recycle(TR1), and batch test III-C, T and compost recycle(TR2). Magnesium addition and compost reutilization had no adverse effect on the degradation of organic matter. Reuse of the compost, however, had a clear effect on the total nitrogen(TN) and total phosphorus(TP) contents in the final compost. Repeated compost reutilization as a bulking material was resulted in composts rich in N and P. Upon adding the Mg supplement to the composting materials, the ortho-phosphate(OP) to TP ratio decreased due to the MAP crystallization reaction. The decrease in the OP/TP ratio and the increase in the TP content of the compost indicate that water-soluble phosphate is converted into a slow-release phosphate by the formation of crystals during composting. X-ray diffraction analysis of the irregular shaped crystals in the compost indicated that they are MAP crystals and that the crystallization of MAP begins immediately after the addition of the Mg supplement. The Mg addition to composting materials and the reutilization of compost as a bulking material would be a practical means to conserve nutrient content.
참고문헌 (19)
- APHA, "Standard Methods for the Examination of Water and Wastewater. 10th Ed., American Public Health Association, Washington, DC", ~ (1995)
- Booker, N. A., "Struvite formation in wastewater treatment plants: Opportunities for nutrient recovery", Environ. Technol., 20, pp.777~782 (1999)
- Bridger, G. L., "Metal ammonium phosphates as fertilizers", J. Agr. Food Chem., 10, pp.181~188 (1962)
- Bueno, P., "Optimizing composting parameters for nitrogen conservation in composting", Bioresource Technol., 99, pp.5069~5077 (2008)
- Chirmuley, D. G., "Struvite precipitation in WWTPs: Causes and solutions", Water(J. Austr. Water Assoc.), 36, pp.21~23 (1994)
- Doyle, J., "Chemical control of struvite precipitation", J. Environ. Eng., 129, pp.419~426 (2003)
- Graves, R. E., "Composting, Chapter 2. In: National Engineering Handbook, Part-637. United States Department of Agriculture, 210-VI-NEH. Washington, DC, USA", ~ (2000)
- Hao, X. D., "Struvite formation, analytical methods and effects of pH and Ca2+", Water Sci. Technol., 58, pp.1687~1692 (2008)
- Hoitink, H. A. J., "Basis for the control of soilborne plant pathogens with composts", Ann. Rev. Phytopathol., 24, pp.93~114 (1986)
- Jeong, Y. K., "Optimum doses of Mg and P salts for precipitating ammonia into struvite crystals in aerobic composting", Bioresource Technol., 96, pp.1~6 (2004)
- Jeong, Y. K., "A new method for conservation of nitrogen in aerobic composting process", Bioresource Technol., 79, pp.129~133 (2001)
- Kirchmann, H., "Ammonia volatilization during aerobic and anaerobic manure decomposition", Plant Soil, 115, pp.35~41 (1989)
- Kithome, M., "Reducing nitrogen losses during simulated composting of poultry manure using adsorbents or chemical amendments", J. Environ. Qual., 28, pp.194~201 (1999)
- Kuroda, K., "Isolation of thermophilic ammonium tolerant bacterium and its application to reduce ammonia emission during composting of animal wastes", Biosci. Biotechnol. Biochem, 68, pp.286~292 (2004)
- Lee, J. E., "Dose effects of Mg and PO4 sources on the composting of swine manure", J. Hazard. Mater, 169, pp.801~807 (2009)
- Munch, E. V., "Controlled struvite crystallisation for removing phosphorus from anaerobic digester sidestreams", Water Res., 35, pp.151~159 (2001)
- Raut, M. P., "Microbial dynamics and enzyme activities during rapid composting of municipal solid waste-A compost maturity analysis perspective", Bioresource Technol., 99, pp.6512~6519 (2008)
- Stentiford, E. I., "Composting control: Principles and practice. in: The Science of Composting, Part 1", pp.29~59 (1996), Blackie
- Zhu, N., "Effect of low initial C", N ratio on aerobic composting of swine manure with rice straw, 2007, pp.98, 9~13