탁주용 곰팡이 고체종국 제조 및 품질 특성
Quality characteristics and preparing of solid starter using fungal strains for Takju
2
조회
0
다운로드
3
인용
0
참고문헌
키워드
초록
In this study, we investigated the effect of fermentation conditions on the amylolytic and proteolytic activities of Aspergillus luchuensis strain 74-5 and Aspergillus oryzae strain 75-2, which are used in the preparation of the starter culture, for Takju (Korean traditional rice wine). The starter culture was optimized using different conditions, such as inoculum size, inoculation temperature, and incubation time. The enzyme activities under each condition were measured. In the A. luchuensis strain 74-5 starter culture, the α-amylase and glucoamylase activities increased, however the activity of acidic protease decreased as the diluent to starter culture ratio increased. In the A. oryzae 75-2 starter culture, all enzyme activities were maintained at a higher level even at 5% inoculation ratio. Higher enzyme activities were observed in the middle range of inoculation temperature (35, 40℃), than in the lower range (20, 30℃). Enzyme activity in the starter culture varied with incubation time, however it was the highest at 144 and 120 hr, respectively, for A. luchuensis strain 74-5 and A. oryzae strain 75-2. The spore count of the starter culture was approximately 2×107 during fermentation, out of which contamination by aerobic bacteria was about 3×103. The results suggested that the starter culture of each strain could be used as an inoculum for fermentation. However, we needs to conduct further research for the selection of suitable diluting agents as well as drying methods to reduce the contamination by aerobic bacteria, while retaining the enzyme activity.
Abstract
In this study, we investigated the effect of fermentation conditions on the amylolytic and proteolytic activities of Aspergillus luchuensis strain 74-5 and Aspergillus oryzae strain 75-2, which are used in the preparation of the starter culture, for Takju (Korean traditional rice wine). The starter culture was optimized using different conditions, such as inoculum size, inoculation temperature, and incubation time. The enzyme activities under each condition were measured. In the A. luchuensis strain 74-5 starter culture, the α-amylase and glucoamylase activities increased, however the activity of acidic protease decreased as the diluent to starter culture ratio increased. In the A. oryzae 75-2 starter culture, all enzyme activities were maintained at a higher level even at 5% inoculation ratio. Higher enzyme activities were observed in the middle range of inoculation temperature (35, 40℃), than in the lower range (20, 30℃). Enzyme activity in the starter culture varied with incubation time, however it was the highest at 144 and 120 hr, respectively, for A. luchuensis strain 74-5 and A. oryzae strain 75-2. The spore count of the starter culture was approximately 2×107 during fermentation, out of which contamination by aerobic bacteria was about 3×103. The results suggested that the starter culture of each strain could be used as an inoculum for fermentation. However, we needs to conduct further research for the selection of suitable diluting agents as well as drying methods to reduce the contamination by aerobic bacteria, while retaining the enzyme activity.
참고문헌 (35)
- 이승주, "누룩원료를 달리하여 제조한 쌀약주의 관능적 특성", 한국식품과학회지, 42(1), pp.119~123 (2010), 한국식품과학회
- 이상선, "각종 누룩 균을 이용한 실험실조건에서의 막걸리 제조", 한국균학회지, 30(1), pp.61~65 (2002), 한국균학회
- 이대형, "약주의 품질 특성에 미치는 효모와 누룩 첨가량의 영향", 한국미생물·생명공학회지, 39(3), pp.274~280 (2011), 한국미생물·생명공학회
- 박창숙, "밀가루 누룩으로 담금한 탁주 술덧의 품질 특성", 한국식품과학회지, 34(2), pp.296~302 (2002), 한국식품과학회
- 배상면, "전통 누룩 첨가 비율과 효모가 약주의 발효 공정 및 품질에 미치는 영향", 동아시아식생활학회지, 18(1), pp.41~48 (2008), 동아시아식생활학회
- Han EH, "Quality characteristics in mash of Takju prepared by using different Nuruk during fermentation", Korean J Food Sci Technol, 29, pp.555~562 (1997)
- Yu TS, "Bibliographical study on microorganisms of traditional Koran Nuruk(since 1945)", J Korean Soc Food Sci Nutr, 27, pp.789~799 (1998)
- 이효형, "전통 누룩 발효과정 중 품질 및 항원성 변화", 한국식품영양과학회지, 38(1), pp.76~82 (2009), 한국식품영양과학회
- Kim HS, "Enzymological characteristics and identification of useful fungi isolated from traditional Korean Nuruk", Kor J Appl Microbiol Biotechnol, 26, pp.456~464 (1998)
- 최정실, "Rhizopus oryzae N174를 이용한 액체종국 저장조건에 따른 밀누룩의 품질특성", 한국미생물·생명공학회지, 40(4), pp.319~324 (2012), 한국미생물·생명공학회[DOI]
- 김민성, "밀의 배합비율과 수분첨가율에 따른 벼누룩 품질특성", 동아시아식생활학회지, 21(6), pp.897~904 (2011), 동아시아식생활학회
- So MH, "Improvement in the quality of Takju by the combined use of Aspergillus kawachii and Aspergillus oryzae", Korean J Food Nutr, 4, pp.115~124 (1991)
- 문지영, "전통누룩에서 분리한 양조용 곰팡이의 배양 특성 연구", 동아시아식생활학회지, 26(2), pp.125~140 (2016), 동아시아식생활학회[DOI]
- So MH, "Takju brewing by combined use of Rhizopus japonicus-Nuruk and Aspergillus oryzae-Nuruk", J Korean Soc Food Nurt, 25, pp.157~162 (1996)
- MacKenzie DA, "Molecular basis of glucoamylase overproduction by a mutagenised industrial strain of Aspergillus niger", Enzyme Microbial Technol, 26, pp.193~200 (2000)
- Thenmozhi M, "Antifungal activity of Streptomyces sp. VITSTK7 and its synthesized Ag2O", Ag nanoparticles against medically important Aspergillus pathogens, 2013, pp.23, 97~103
- Park IS, "Some factors affecting glucoamylase production from Aspergillus sp", Kor J Appl Microbiol Bioeng, 17, pp.519~523 (1989)
- 유대식, "신종 누룩사상균, Aspergillus coreanus NR 15-1의 α-Amylase의 효소학적 특성", KSBB Journal, 19(4), pp.301~307 (2004), 한국생물공학회
- SO MH, "Characteristics of Koji molds isolated from Koji-starters for brewing in Korea and Japan", Korean J Food Nutr, 6, pp.1~7 (1993)
- & geography-Global Trends & Forecast to 2018, "Marketsandmarkets", 1~240 (2014)
- Jeon CO, "Industrial application and starter development for traditional fermentation food using lab evolution method", E-bioindustry, 27, pp.1~4 (2014)
- Uyeno K, "Report of examination of Corean"Koji"(Ⅰ)", Yakugaku Zasshi, 277, pp.203~212 (1906)
- Yu TS, "Bibliographical study on microorganisms of nuruk (until 1945)", J Korean Soc Food Sci Nutr, 25, pp.170~179 (1996)
- Yu TS, "Bibliographical study on microorganisms of traditional Koran Nuruk (since 1945)", J Korean Soc Food Sci Nutr, 27, pp.789~799 (1998)
- Park JW, "Identification of filamentous molds isolated from Korean traditional Nuruk and their amylolytic activities", Kor J Appl Microbiol Biotechnol, 23, pp.737~746 (1995)
- Kim HS, "Characteristics of useful fungi isolated from traditional Korean Nuruk", J Korean Soc Food Sci Nutr, 26, pp.767~774 (1997)
- Jo GY, "Isolation and identification of the fungi from Nuruk", J Korean Soc Food Sci Nutr, 26, pp.759~766 (1997)
- Hong SB, "Taxonomic re-evaluation of black Koji molds", Appl Microbiol Biotechnol, 98, pp.555~561 (2014)
- 정은주, "벼 도정 부산물을 이용한 탁주 제조에 관한 연구", 한국식품영양학회지, 17(2), pp.199~205 (2004), 한국식품영양학회
- NTS liquors license support center, "Liquors Analysis Code", 18~ (2014)
- Brewing society of Japan, "The Annotation of the official method of analysis of the national tax administration agency. 4th ed", 218~226 (1993)
- Somogyi M, "Notes on sugar determination", J Biol Chem, 195, pp.19~23 (1952)
- 소명환, "쌀 입국 제조시 Rhizopus sp.ZB9의 배양 조건이 프로테아제 생성에 미치는 영향", 한국식품영양학회지, 23(3), pp.399~404 (2010), 한국식품영양학회
- Atlas RM, "Laboratory manual of experimental microbiology", pp.119~127 (1995), Mosby Publlishers
- 최정실, "Aspergillus 속 곰팡이를 이용한 액체종국 제조 및 밀누룩의 품질특성", 한국미생물·생명공학회지, 39(4), pp.357~363 (2011), 한국미생물·생명공학회