Velocity and temperature profiles of Al/water micro fluid in a circular tube with swirl
2
조회
0
다운로드
0
인용
0
참고문헌
키워드
초록
A lot study of convection heat transfer on internal flow has been extensively conducted in the past decades using of high specific surface area, increasing heat transfer coefficient, swirling flow and improving the transport properties. This study concerned with the application of a tangential slot swirl generator for improving heat transfer in a horizontal circular copper tube. The Al particles(about 100~130μm) was employed for this experimental work. 3D PIV(particle image velocimetry) technique has employed to measure velocity profiles of Al particles with and without swirl flow. The copper tube is heated uniformly by winding of a heating coil for heat transfer work, having a resistance of 9 ohm per meter. Experiments are performed in the Reynolds number range of 6,800~12,100 with swirl and without swirl using Al particles. Experimental data for comparison of Nusselt number is presented that of with swirl and without swirl along the test tube for the Reynolds numbers. The Nusselt number is improved with increasing of Reynolds numbers or swirl intensities along the test tube. The Nusselt number with swirl flow is about 60.0% to 119.0% higher than that obtained by the Dittus–Boelter equation.
Abstract
A lot study of convection heat transfer on internal flow has been extensively conducted in the past decades using of high specific surface area, increasing heat transfer coefficient, swirling flow and improving the transport properties. This study concerned with the application of a tangential slot swirl generator for improving heat transfer in a horizontal circular copper tube. The Al particles(about 100~130μm) was employed for this experimental work. 3D PIV(particle image velocimetry) technique has employed to measure velocity profiles of Al particles with and without swirl flow. The copper tube is heated uniformly by winding of a heating coil for heat transfer work, having a resistance of 9 ohm per meter. Experiments are performed in the Reynolds number range of 6,800~12,100 with swirl and without swirl using Al particles. Experimental data for comparison of Nusselt number is presented that of with swirl and without swirl along the test tube for the Reynolds numbers. The Nusselt number is improved with increasing of Reynolds numbers or swirl intensities along the test tube. The Nusselt number with swirl flow is about 60.0% to 119.0% higher than that obtained by the Dittus–Boelter equation.
참고문헌 (16)
- R. Saidur, "A review on applications and challenges of nano fluids", Renewable and Sustainable Energy Review, 15(3), pp.1646~1668 (2011)
- Ravikanth S. Vajjha, "A review and analysis on influence of temperature and concentration of an fluids on thermophysical properties", Heat Transfer and Pumping Power, International journal of heat and mass transfer, 55(15), pp.4063~4078 (2012)
- Zoubida Haddad, "A review on natural convective heat transfer of nano fluids", Renewable and Sustainable Energy Review, 16(7), pp.5363~5378 (2012)
- H. A. Mohammed, "Convective heat transfer and fluid flow over a step using nano fluids", Renewable and Sustainable Energy Review, 15, pp.2921~2939 (2011)
- S. M. Sohel Murshed, "A review of boiling and convective heat transfer with nanofluids", Renewable and Sustainable Energy Review, 15(5), pp.2342~2354 (2011)
- Govarthan Pathipakka, "Heat transfer behavior of nano fluids in a uniformly heated circular tube fitted with herical inserts in laminar flow", Superlattices Microstructures, 47, pp.349~360 (2010)
- Adrian Neild, "Swirl mixing at micro fluidic junctions due to low frequency side channel fluidic perturbations", Sensors and Actuators B, 150(2), pp.811~818 (2010)
- Svetlana Popovic, "Twisted tapes as turbulence promoters in the microfiltration of milk", Journal Membrane Science, 384(1), pp.97~106 (2011)
- L. Syam Sundar, "Turbulent heat transfer and friction factor of Al2O3 nano fluid in circular tube with twisted tape inserts", Journal of Heat and Mass Trasfer, 53, pp.1409~1416 (2010)
- Yunus A. Cengel, "Heat Transfer", pp.441~ (2003), GrawHill
- F. J. Wasp, "Solid-liquid Flow Slurry Pipeline Transportation" (1977), Trans. Tech, Publication
- R. S. Vajjha, "Density measurements of different nano fluids and their comparison with theory", Petro, Sci. Tech, 27(6), pp.612~624 (2009)
- B. C. Pak, "Hydrodynamic and heat transfer study of dispersed fluids with submicron metallic oxide particles", Experimental Heat Transfer, 11(2), pp.151~170 (1998)
- B. C Sahoo, "Determination of rheological behaviour of aluminium oxides and development of new viscosity correlations", Petro. Sci. Tech, 27(15), pp.1757~1770 (2009)
- J. Buongiorno, "Convective transport in nano fluids", Journal of Heat and Mass Transfer, 128, pp.240~250 (2006)
- R. L. Hamilton, "Thermal conductivity of heterogeneous two component system, I and EC", Industrial & Engineering Chemistry Fundamentals, 1(3), pp.187~191 (1962)